kohler command pro 15 won 't start

Randy....did you remove the flywheel key to inspect it..? Make sure there isn't any water in the gas... Next step is to check your compression... If you have good fuel...good spark...and good compression....and it won't run....

JustAnswer

justanswer.com › small-engine › bkkyt-kohler-command-pro-cv15t-won-t-start.html

Kohler Command Pro CV15T Won't Start - Expert Q&A

For the Kohler Command Pro CV15T, set both intake and exhaust valves at TDC on the compression stroke. Loosen the set screw and adjust valve lash to .004 inches using a feeler gauge. Ensure the push rod is fully compressed into the hydraulic lifter while adjusting to avoid incorrect clearance.

Videos

15:54

YouTube

Disassembly of the Kohler K241 (valves) - YouTube

Kohler Courage - Intake Valve Leak FIX - YouTube

Kohler Engine Valve Adjustment - YouTube

May 28, 2017

youtube.com

KOHLER Command Twin Cylinder Engine. WON'T START or ...

13:30

YouTube

Mower runs for 5 minutes, then dies....How to fix it - YouTube

May 13, 2019

View all

Adventure Rider

advrider.com › f › threads › kohler-command-pro-15-engine-starts-runs-wont-crank-from-key.1552079

Kohler Command Pro 15 Engine Starts & Runs-won't Crank From Key | Adventure Rider

My Woodmizer sawmill engine baffles me? It's the original engine from about 2001. I just replaced both the starter solenoid and the ignition key...

Lawn Care Forum

lawnsite.com › home › forums › equipment › 🔧 mechanic and repair

kohler wont stay running | Lawn Care Forum

That could be the problem. You could check it by disconnecting the fuel line, sticking it in a small bottle and cranking the engine over. The pump is also often higher than the fuel tank or the carb to prevent siphoning.

Cub Cadet

ccpartsnmore.com › cub-cadet-blog

Troubleshoot your Kohler Command Pro Engine

Many of your outdoor power equipment tools are powered by a reliable Kohler engine. On the occasion you find your Kohler engine performing less than optimally, use our troubleshooting guide to diagnose the issue at home. If you need to lookup a replacement part or schedule service for your ...

JustAnswer

justanswer.com › small-engine › 548up-15-hp-kohler-command-motor-will-not-start.html

Troubleshooting Kohler 15 HP Engine Problems: Expert Q&A

Eng model CV15S, SPEC 41597 ... Remove the rocker cover and examine the valves and push rods. If no problem found, it might be time to check the flywheel key,as it could shear and throw engine out of time.

JustAnswer

justanswer.com › small-engine › pegw8-need-talk-technician-kohler-15-horse.html

Kohler 15 Horse Won't Start? Expert Help & Contact Info

For a Kohler 15 Horse engine that won’t start, first check the spark plug for fouling or damage. Inspect the ignition coil and wiring connections for corrosion or breaks. Ensure the fuel tank has fresh gasoline and the fuel filter is clean.

My Tractor Forum

mytractorforum.com › home › forums › tractor talk › small engines and repair

Kohler Command 15, Can't get starter to turn engine to start | My Tractor Forum

A recoil that should fit was provided on a Snapper 33148KVE Kohler Model CV14ST Spec 1422 Ser 2104402314 I would take the new starter out of the picture by using the one you know works from the other engine. Then if you have a problem, it would be due to either battery state of charge or the relays and cables providing the path for power to reach the starter.

My Tractor Forum

mytractorforum.com › home › forums › lawn and garden tractors › lawn and garden tractors by brand › craftsman/sears forum

Kohler CV15 Starts and Dies Immediately | My Tractor Forum

This is my 1996, I believe, original to me 917.956591 15.5 Command with 42" deck. It is the Kohler CV15 engine and has a Nikki carb. Today, I was mowing for spring cleanup running just fine, turned to go the other way and she shut down and died. I am on my third carb and the issue has always been the shutoff solenoids.

Find elsewhere

Google Bing Mojeek

BobIsTheOilGuy

bobistheoilguy.com › home › forums › motorcycles, boating, small engine, aviation, powe › lawn mower and small engine

New starter won't start kohler 15 horsepower. | BobIsTheOilGuy

February 25, 2024 - Have you tried to energize the starter directly with a cable. Click to expand... +1 Try applying power directly to the starter with jumper cables from the battery. If it does nothing the starter is fried (likely with an Amazon starter) but if it spins over, you have other electrical problems, ...

My Tractor Forum

mytractorforum.com › home › forums › tractor talk › small engines and repair

Kohler Command Pro 20 HP won't start or won't stay running. | My Tractor Forum

check that the choke & throttle plates move appropriately try starting the engine for a bit, then look at the spark plug (is it wet or dry, does it look like the engine was running lean or rich or burning oil) Actually, I would suggest finding ...

Repair Clinic

repairclinic.com › home › repair help › kohler small engine repair › kohler small engine won't start repair

Kohler Small Engine Won't Start | Solutions & Repair Parts | Repair Clinic

03:17

If the recoil starter assembly is not working properly, replace it. ... If the start switch is difficult to turn or works intermittently, replace it. To determine if the start switch is defective, use a multimeter to test it for continuity.

Published November 22, 2021

Lawn Care Forum

lawnsite.com › home › forums › equipment › 🔧 mechanic and repair

Kohler command pro 15 issues | Lawn Care Forum

Hopefully it wont get much worse and could last ya fer quite a while. You can rub a small amount of moly paste/ assy. lube in the spot, might help a bit. Obviously ya don't feel like checking out the rings, so... Jes' slap a head gasket on it. Oh, yeah...don't ferget to fix the leakin' inlet needle in the carb. Ya may wanna stick a shut-off valve in the fuel line. ... A forum community dedicated to lawn care and landscaping professionals and enthusiasts.

Hobbyist Forums

hobbytalk.com › home › forums › small engine repair › small engine repair 4-cycle

Kohler Command Pro 20 starts then dies | Hobbyist Forums

I was wondering if it was a safety switch issue. Let me know. ... i would check the fuel shut off solenoid make sure it has power to it , and is grounded :thumbsup: also might check ground to" coil " i would disconnect kill wire and try it , also you can check the key switch and safety switches by hooking your test light on the + side of battery , turn key to on position if light stays on then it could be the switch or switches sounds to my like the key switch , but if you take the kill wire off @ the " coil" it will eliminate all wires just my 2 cents :thumbsup: i would make sure the wires are plugged in good at the wiring harness and clean the one near the engine , might be @ worst the speed advance module , but that would be where i went last , could be tank venting

iFixit

ifixit.com › Answers › View › 174112 › 16+Hp+Kohler+engine.+Won't+Start,+no+fire.+Why

SOLVED: 16 Hp Kohler engine. Won't Start, no fire. Why? - Craftsman Riding Mower - iFixit

Top answer

1 of 5

Read the spark plug first to try to see what has been going on. A plug in normal condition has a thin layer of light-brown deposits on it. If you see a thick layer of black carbon deposits, it's a sign that the carburetor mixture is too rich -- your engine may even be smoking. Electrodes that have been worn thin are a sign of overheating, often caused by too much ethanol in the gas. If your plug has wet, oily deposits, it's time to take the mower in for servicing, because oil is leaking into the combustion chamber where it shouldn't be. · Other Engine Problems · If your spark plug appears to have normal wear -- or if you've just installed a new one -- and the engine doesn't fire, you can check the plug by replacing the spark plug wire with a tester and pulling the starting rope. If you don't see a spark on the tester, there may be a problem with the ignition coil of the flywheel to which it's attached. The ignition coil doesn't frequently develop problems, but the connection between the flywheel and coil or between the starting pulley and flywheel can wear out, and the coil may not be turning. Replacing the worn part isn't difficult, but you may need a pro to properly disassemble the engine.

2 of 5

try removing the white wire that worked on my mower

JustAnswer

justanswer.com › small-engine › affhx-starter-kholer-command-pro-spins-won-t.html

Kohler Engine Starter Not Engaging: Expert Solutions & Troubleshooting

There are only two reasons why the starter will not engage the flywheel: low voltage or if the positive and negative connections are reversed, causing it to turn backwards! ... Disclaimer: The customer and expert messages presented herein may ...

Repair Clinic

repairclinic.com › RepairHelp › How-To-Fix-A-Small-Engine › 164-315-- › Kohler-Small-Engine-Stops-After-A-Few-Seconds

Kohler Small Engine Stops After A Few Seconds | Solutions & Repair Parts | Repair Clinic

01:49

If the fuel cap vent is clogged, air won’t be able to enter the tank and a vacuum or “vapor lock” will occur. This stops the flow of fuel to the carburetor causing the engine to stall. To determine if the fuel cap vent is clogged, try slightly loosening the cap and then starting the engine. If loosening the fuel cap allows the engine to stay ru...nning it is likely clogged and will need to be replaced. ... Kohler Small Engine Adhesive Replacement PartsKohler Small Engine Alternator, Battery & Charger Replacement PartsKohler Small Engine Auger Replacement PartsKohler Small Engine Axle, Ro

Published November 30, 2021

reddit.com › r/smallengines › kohler command pro 25 - stalls after 35 mins of running good, won't stay running after. fixes itself after 30 minutes of waiting.

r/smallengines on Reddit: Kohler Command Pro 25 - Stalls after 35 mins of running good, won't stay running after. Fixes itself after 30 minutes of waiting.

May 22, 2024 -

I have a Simplicity Legacy 25hp (sub-compact tractor) with a Kohler Command Pro. It has 1100 hours on it, so its by no means a new tractor.

It has a problem now where it will run for 35+minutes, cut really good (no extra choke or anything like that), then suddenly bog down and die. it starts right back up but immediately dies as if its getting no gas (choke helps it stay up for a little longer but not much)

I've tried

New sparkplugs
gas cap off (vapor lock)
running each cylinder individually. It starts with either cylinder running seperately but still dies immediately after.

both cylinders get spark. The fuel filter has gas in it.

It doesn't smell like gas, get red hot, or make any smoke but the muffler is in pretty poor shape (original from early 00s) and it sounds like a cammed muscle-car so im guessing that is causing some extra heat. but i feel like there must be something else going on. So im wondering if anyone here has any other diagnosis steps i can take to pinpoint the issue?

I really dont want to take the carb off if i dont have to, so im planning on running a fuel cleaner. aside from that, maybe new coils?